3.0d M57

The strongest engine in the range. Bottom ends routinely pass 400,000 km; everything that fails on it's bolted to the outside and priced accordingly.

Overview

The 3.0d is the M57 diesel version of the BMW X5 SUV (E70), sold 2007–2010 with 235 PS and auto_6_zf. High risk at level 4. Air suspension, the transfer case actuator and a set of tyres each cost a large share of the car. 8 failure modes are recorded against its engine, gearbox, chassis and shared components. Prices on this page are illustrative placeholders rather than a sourced market sample. See the methodology for how the bands are derived.

BMW X5 SUV (E70) · photo BMW E70 X5 3,0d pre-facelift by JaayJay · Public domain · Wikimedia Commons

Power235 PS

Torque520 Nm

Years2007–2010

Fueldiesel

DrivexDrive

EnginesM57

Biggest risks

Ranked by probability × repair cost. 8 recorded in total.

41Fragile

Transfer case actuator seizure€500–€2,600partly checkable
"Lifetime" fluid neglect€400–€2,500partly checkable
DPF clogging and forced regeneration€250–€1,800partly checkable

Risk level −33 · Likely spend vs price −26 · all issues →

System by system9 systems reviewed · 4 with no recurring fault reported

EnginewatchOil filter housing gasket leak, €300–€600.+1 more in this system

Fuel systemwatchInjector seal leak (soot around injectors), €400–€1,400.

Turbo & intakewatchVariable-vane turbo actuator sticking, €400–€1,200.

Cooling✓ clearNo recurring fault reported for this system on this engine.

Emissions⚠ attentionDPF clogging and forced regeneration, €250–€1,800.

Transmission⚠ attentionTransfer case actuator seizure, €500–€2,600.+2 more in this system

Electrics✓ clearNo recurring fault reported for this system on this engine.

Suspension & brakes✓ clearNo recurring fault reported for this system on this engine.

Body & interior✓ clearNo recurring fault reported for this system on this engine.

Pre-facelift or facelift, this engine spans both

The same badge either side of the changeover. Bands are split at the facelift year from the generation record.

Phase	Years	Low	Average	High	Good buy	What differs
pre Pre-facelift	2007–2009	€6,500	€10,500	€16,000	€8,500	The specification the car launched with.
LCI Facelift (LCI)	2010	€7,100	€11,450	€17,450	€9,300	N55 replaced N54 and N57 replaced M57; Eight-speed automatic fitted; Revised nose and lights

Known issues, ranked by expected cost

Faults recorded against this engine, its components and its chassis, ranked by likelihood × repair cost. Costs are indicative ranges with a stated labour basis.

Transfer case actuator seizureE70 body€500–€2,600

A four-wheel-drive warning, a grinding or clicking from under the centre of the car, and in later stages a transmission fault light. The servo actuator that controls the clutch inside the transfer case seizes, and the motor then damages the case as it tries to move it. Catching it at the actuator stage is the difference between a moderate bill and a large one.

Check: Scan for stored transfer case faults rather than relying on the dashboard, since the warning arrives late. Listen underneath at low speed for clicking, and ask whether the actuator has ever been replaced.

DrivetraincommonPartly detectableevidence: documented90–180k km

"Lifetime" fluid neglectZF 6HP19 / 6HP21 six-speed automatic€400–€2,500

Harsh or hunting shifts, a shunt between second and third, delayed engagement when cold. BMW declared the fluid a lifetime fill. It's not. Fluid degrades, the valve body wears, and the box eventually fails.

Check: Drive it from cold through every gear, then in manual mode. Ask when the fluid was last changed. "It's sealed for life" means never, and you should price a service in.

TransmissioncommonPartly detectableevidence: documented120–200k km

DPF clogging and forced regenerationDPF€250–€1,800

Warning light, limp mode, oil level rising above the maximum mark from fuel dilution. The filter needs sustained hot running to regenerate. A car used for short urban trips never completes a regeneration cycle.

Check: Read the DPF soot load and the distance since the last regeneration on a scan tool, and check the engine oil level and smell it for diesel. Ask what the car was used for. A short-trip city diesel is the wrong car regardless of mileage.

EmissionscommonPartly detectableevidence: documented120–250k km

Variable-vane turbo actuator stickingvariable-vane turbo€400–€1,200

Sudden loss of power on a hard pull, limp mode that clears on restart, underboost or overboost codes. Soot binds the variable vanes or the actuator linkage seizes.

Check: Do a full-throttle pull in third from 1,500 rpm to the limiter. Hesitation or a drop into limp mode is this fault. Do this twice.

Turbo & intakecommonDetectable at viewingevidence: documented130–250k km

Oil filter housing gasket leakoil filter housing€300–€600

Oil pooling on the subframe, oil on the serpentine belt, drips on the driveway. The gasket between the filter housing and the block fails. Oil then lands on the belt, and a belt that shreds can be drawn into the front crank seal.

Check: Put the car on a lift. Check the belt itself for oil contamination. An oily belt is the version of this fault that ends badly.

EnginecommonDetectable at viewingevidence: documented90–170k km

Mechatronic sleeve and pan gasket leakZF 6HP19 / 6HP21 six-speed automatic€250–€600

Fluid on the bellhousing or the exhaust, gearbox fault warnings, erratic shifting once the level drops. The plastic adapter sleeve carrying the wiring through the case hardens and leaks; the integrated pan gasket does the same.

Check: On the lift, look at the gearbox pan and the bellhousing seam for wet ATF, it's red-brown and unmistakable.

TransmissioncommonDetectable at viewingevidence: documented120–220k km

Injector seal leak (soot around injectors)M57D30TU2 / M57D30TOP€400–€1,400

Ticking that grows louder, black soot deposits around the injector bases, diesel smell in the cabin. Copper sealing washers fail and combustion gases track past the injector, eventually welding it into the head.

Check: Remove the engine cover and look at the base of each injector for black crusting. Caught early this is cheap; ignored it's a cylinder head job.

FueloccasionalDetectable at viewingevidence: documented150–300k km

Swirl flap wear and ingestionswirl flaps€400–€900

Often none until it happens. Rough running, then in the worst case an engine destroyed by an ingested flap. The intake manifold's swirl flaps run on spindles that wear. A detached flap can be drawn into a cylinder.

Check: Not visible without removing the manifold. Ask whether the flaps have been removed or the manifold replaced. Many well-kept examples have had this done preventively, and that's a selling point.

EngineoccasionalNot detectable at viewingevidence: documented120–250k km

Ranked by probability × repair cost, not by how loudly a failure is discussed. Inherited from the engine, gearbox, chassis and shared components, each written once.

Pre-purchase inspection

The same issue records, reordered into the sequence you can actually check them in: cold start, static, drive, paperwork.

8 checks · saved in this browser ·

1Static checksEngine off, ideally on a lift.

Oil filter housing gasket leakPut the car on a lift. Check the belt itself for oil contamination. An oily belt is the version of this fault that ends badly.Mechatronic sleeve and pan gasket leakOn the lift, look at the gearbox pan and the bellhousing seam for wet ATF, it's red-brown and unmistakable.Injector seal leak (soot around injectors)Remove the engine cover and look at the base of each injector for black crusting. Caught early this is cheap; ignored it's a cylinder head job.

2On the driveInclude low-speed manoeuvring, not just an open road.

"Lifetime" fluid neglectDrive it from cold through every gear, then in manual mode. Ask when the fluid was last changed. "It's sealed for life" means never, and you should price a service in.Variable-vane turbo actuator stickingDo a full-throttle pull in third from 1,500 rpm to the limiter. Hesitation or a drop into limp mode is this fault. Do this twice.

3PaperworkOn these cars the folder is most of the value.

Swirl flap wear and ingestionNot visible without removing the manifold. Ask whether the flaps have been removed or the manifold replaced. Many well-kept examples have had this done preventively, and that's a selling point.

4OBD scanMandatory. A seller who refuses a scan has answered the question.

Transfer case actuator seizureScan for stored transfer case faults rather than relying on the dashboard, since the warning arrives late. Listen underneath at low speed for clicking, and ask whether the actuator has ever been replaced.DPF clogging and forced regenerationRead the DPF soot load and the distance since the last regeneration on a scan tool, and check the engine oil level and smell it for diesel. Ask what the car was used for. A short-trip city diesel is the wrong car regardless of mileage.

Mileage and servicing

What the odometer does and doesn't tell you here, plus the service items whose neglect causes the expensive failures above.

The engine will outlast the rest of the vehicle, so mileage is the wrong thing to fixate on. What ages is the suspension, the electronics and the driveline, and those follow time and load rather than distance.

Service item	Interval	Cost
Transfer case actuator check A seized actuator damages the transfer case and the repair is large.	annually	€0–120 to inspect
Engine oil and filter Turbo and chain life both depend on it.	15,000 km or annually	€130–200

What to pay

What this engine sells for, against the median of every engine in the chassis. All figures are illustrative placeholders. See the basis chips.

median €11k

€6.5k€8.5k€17.4k

Cheapfind the reasonGood buyif it checks outFairnormal moneyOverpricedneeds justifying

Asking price (€)Mileage (km)

Enter an asking price to get a verdict against this variant's band: cheap, fair, good buy or overpriced.

United States vs Europe

1 EUR = 1.08 USD · 2026-07

🇪🇺 Europe · EUR€8,500band €6,500–€17,450

🇺🇸 United StatesNot sold3.0d M57 was never a US-market car

What that meansNo US band exists to compare. Any car you find there's a private import, parts and specialist knowledge are thinner, and the price says more about import cost than about the market.

US figures are the EU band converted at a stated rate. No US market differential is modelled: we hold no sourced US asking prices, and inventing one would be worse than saying so. What the comparison does show for real is availability. Most of this range was never sold in the US.

ModelBMW X5 3.0d
ChassisE70
EngineM57
Years2007–2010
MarketCentral EU
Windowrolling 12 months to 2026-07

Good buy at or under the marker · Median asking price · bar spans the 10th to 90th percentile · dashed line is the e70 median, all 3 engines

Good buy isn't the same as cheapest. The good-buy figure assumes the known failure items are either done with receipts or verifiably not yet due. Full breakdown by facelift phase →

Buyer notes

Our judgement, kept separate from the records it's built on.

Our read, not a record

An E70 is fast, quiet and still drives smaller than it is, which is why they sell so well used. The arithmetic that catches people is consumables, since four tyres cost what a whole repair costs on an ordinary car. Check the air suspension at every height if fitted and listen for the transfer case actuator, because that's a common and awkward failure. So scan the whole car rather than the engine alone, and treat scattered electrical faults as a battery problem until proven otherwise.

Everything above this line comes from the issue and specification records. This paragraph is our judgement on top of them. See how we reach it.

Full specification

Manufacturer figures for this engine and body, as recorded in the variant and engine data.

Engine code	M57D30TU2 / M57D30TOP
Configuration	I6, turbodiesel (twin-turbo in 335d) · 2993 cc
Fuel / injection	diesel · common rail
Model years	2007–2010
Facelift phase	Sold either side of the 2010 facelift, 2007–2009 pre, 2010 LCI
Power / torque	235 PS · 520 Nm
Transmissions	6-speed automatic (ZF)
Gearbox families	ZF 6HP19 / 6HP21 six-speed automatic
Drivetrain	xDrive
Economy (real-world)	8–10 l/100 km mixed
Markets	EU