Car Model Guide/ Toyota/ Avensis/ T27 Tourer/ 2.0 D-4D

2.0 D-4D 1AD-FTV

The smaller of the two Toyota diesels and the safer one. It avoids the head trouble of its 2.2 sibling, so what's left is ordinary modern-diesel care: the particulate filter, the EGR and the turbo actuator.

Overview

The 2.0 D-4D is the 1AD-FTV diesel version of the Toyota Avensis wagon (T27 Tourer), sold 2009–2015 with 126 PS and manual_6. Manageable at level 2. It avoids the head trouble of the 2.2, so what's left is ordinary modern-diesel care around the filter, the EGR and the turbo. 12 failure modes are recorded against its engine, gearbox, chassis and shared components. Prices on this page are illustrative placeholders rather than a sourced market sample. See the methodology for how the bands are derived.

Toyota Avensis wagon (T27 Tourer) · photo Toyota Avensis Combi 1.8 Executive (III, Facelift) – Frontansicht, 28. April 2012, Düsseldorf by M 93 · CC BY-SA 3.0 de · Wikimedia Commons

Power126 PS

Torque310 Nm

Years2009–2015

Fueldiesel

DriveFWD

Engines1AD-FTV

Biggest risks

Ranked by probability × repair cost. 12 recorded in total.

63Demands diligence

DPF clogging and forced regeneration€250–€1,800partly checkable
Front control arm bushing wear€300–€700checkable
Run-flat tyres and kerbed or cracked wheels€150–€900checkable

Risk level −11 · Likely spend vs price −26 · all issues →

System by system9 systems reviewed · 3 with no recurring fault reported

Engine✓ clearNo recurring fault reported for this system on this engine.

Fuel system✓ clearNo recurring fault reported for this system on this engine.

Intake & air✓ clearNo recurring fault reported for this system on this engine.

CoolingwatchCoolant expansion tank cracking, €120–€250.

Emissions⚠ attentionDPF clogging and forced regeneration, €250–€1,800.+1 more in this system

TransmissionwatchxDrive transfer case actuator failure, €600–€1,200.

ElectricswatchFootwell module (FRM) failure, €150–€700.+2 more in this system

Suspension & brakeswatchFront control arm bushing wear, €300–€700.+2 more in this system

Body & interiorwatchCorrosion at the rear subframe and arch seams, €300–€2,000.+1 more in this system

Pre-facelift or facelift, this engine spans both

The same badge either side of the changeover. Bands are split at the facelift year from the generation record.

Phase	Years	Low	Average	High	Good buy	What differs
pre Pre-facelift	2009–2014	€3,400	€5,300	€8,550	€4,350	The specification the car launched with.
LCI Facelift (LCI)	2015	€3,750	€5,800	€9,300	€4,800	New nose, lights and interior; Revised suspension and sound insulation

Known issues, ranked by expected cost

Faults recorded against this engine, its components and its chassis, ranked by likelihood × repair cost. Costs are indicative ranges with a stated labour basis.

DPF clogging and forced regenerationDPF€250–€1,800

Warning light, limp mode, oil level rising above the maximum mark from fuel dilution. The filter needs sustained hot running to regenerate. A car used for short urban trips never completes a regeneration cycle.

Check: Read the DPF soot load and the distance since the last regeneration on a scan tool, and check the engine oil level and smell it for diesel. Ask what the car was used for. A short-trip city diesel is the wrong car regardless of mileage.

EmissionscommonPartly detectableevidence: documented120–250k km

Front control arm bushing wearE9x chassis€300–€700

Knocking over bad surfaces, vague or wandering steering, uneven front tyre wear, steering shimmy under braking. The front lower arm bushings are a known wear item on this chassis and go well before the ball joints.

Check: Drive over a rough road at low speed with the windows down and listen. Check the inside edges of the front tyres for feathering.

SuspensionuniversalDetectable at viewingevidence: documented80–150k km

Run-flat tyres and kerbed or cracked wheelsE9x chassis€150–€900

Harsh ride, vibration at speed, slow punctures. Stiff-sidewall run-flats transmit impacts straight into the rim, and these alloys crack rather than bend.

Check: Inspect the inner rim edge of every wheel for cracks and hairline splits, not just the face for kerbing. Budget for a set of conventional tyres; most owners switch and the ride improves markedly.

SuspensioncommonDetectable at viewingevidence: documented

Corrosion at the rear subframe and arch seamsE9x chassis€300–€2,000

Bubbling at the rear arch lip, scaling on subframe mounting points and rear suspension components. Age plus road salt. This generation isn't a notorious rotter, but nothing from 2005–2013 is immune in a salted market.

Check: Put it on a lift and look at the rear subframe mounting points and the arch lips from behind. Largely a non-issue on cars from southern Europe, a real one on northern and Baltic cars.

Body & corrosionoccasionalDetectable at viewingevidence: documented

Footwell module (FRM) failureE9x chassis€150–€700

Headlights, indicators, windows, wipers and central locking stop working at once, usually right after a battery change or a jump start. The module's memory corrupts when supply voltage dips. It is the single most common electrical failure on this generation.

Check: Test every window, both mirrors, the wipers, all exterior lights and the central locking before you drive. If any cluster of these is dead, this is why.

ElectricalcommonDetectable at viewingevidence: documented

Rear shock mount wearE9x chassis€250–€500

Knock from the rear over speed bumps, a hollow thump from the boot area. The rubber mounts perish. On hard-used cars the mount can crack the surrounding turret metal, which is a far bigger job.

Check: Lift the boot floor and look at the top of the shock towers for cracking or a lifted mount. Listen for a knock over bumps.

SuspensioncommonDetectable at viewingevidence: documented100–180k km

xDrive transfer case actuator failureE9x chassis€600–€1,200

Grinding or binding at low-speed full lock, 4x4 warning lights, a shudder when manoeuvring. The actuator motor and the transfer case's internal chain wear, especially on cars run with mismatched tyre sizes.

Check: Full-lock circles in both directions in a car park, slowly, listening for binding. Check all four tyres are the same brand and wear, mismatched tyres destroy these.

DrivetrainoccasionalDetectable at viewingevidence: documented120–220k km

EGR cooler leakEGR cooler€400–€1,000

Coolant loss with no visible external leak, white smoke, sweet smell. The EGR cooler cracks internally and leaks coolant into the intake. BMW recalled affected diesels over a fire risk from glycol deposits igniting.

Check: Check coolant level and look for unexplained top-ups in the service history. Verify the recall was carried out. It's free and searchable by VIN.

EmissionsoccasionalPartly detectableevidence: manufacturer120–250k km

Ranked by probability × repair cost, not by how loudly a failure is discussed. Inherited from the engine, gearbox, chassis and shared components, each written once. All 12 issues in full →

Mileage and servicing

What the odometer does and doesn't tell you here, plus the service items whose neglect causes the expensive failures above.

Journey history matters most. A car that only ever did short trips will have a stressed filter and a coked EGR whatever the odometer says.

Service item	Interval	Cost
DPF regeneration Short-trip use blocks the filter	regular longer runs	€400–1,100 if blocked
EGR cleaning Carbon builds up on short-run cars	as it fouls	€200–450
Engine oil Turbo and emissions life follow oil quality	on time, correct spec	€80–130

What to pay

What this engine sells for, against the median of every engine in the chassis. All figures are illustrative placeholders. See the basis chips.

median €5.5k

€3.4k€4.3k€9.3k

Cheapfind the reasonGood buyif it checks outFairnormal moneyOverpricedneeds justifying

Asking price (€)Mileage (km)

Enter an asking price to get a verdict against this variant's band: cheap, fair, good buy or overpriced.

United States vs Europe

1 EUR = 1.08 USD · 2026-07

🇪🇺 Europe · EUR€4,350band €3,400–€9,300

🇺🇸 United StatesNot sold2.0 D-4D 1AD-FTV was never a US-market car

What that meansNo US band exists to compare. Any car you find there's a private import, parts and specialist knowledge are thinner, and the price says more about import cost than about the market.

US figures are the EU band converted at a stated rate. No US market differential is modelled: we hold no sourced US asking prices, and inventing one would be worse than saying so. What the comparison does show for real is availability. Most of this range was never sold in the US.

ModelToyota Avensis 2.0 D-4D
ChassisT27 Tourer
Engine1AD-FTV
Years2009–2015
MarketCentral EU
Windowrolling 12 months to 2026-07

Good buy at or under the marker · Median asking price · bar spans the 10th to 90th percentile · dashed line is the t27 tourer median, all 4 engines

Good buy isn't the same as cheapest. The good-buy figure assumes the known failure items are either done with receipts or verifiably not yet due. Full breakdown by facelift phase →

Buyer notes

Our judgement, kept separate from the records it's built on.

Our read, not a record

The 2.0 D-4D is the quieter recommendation in the Avensis range, because it delivers most of the economy of the 2.2 while sidestepping the cylinder-head distortion that gave the bigger engine its reputation. It's not fast, though the torque makes it easy to drive. So treat it as any modern diesel: ask about journey type, look for evidence the EGR and filter have been kept healthy, and avoid a town-only car. Done that way, it's a durable and very cheap thing to run.

Everything above this line comes from the issue and specification records. This paragraph is our judgement on top of them. See how we reach it.

Full specification

Manufacturer figures for this engine and body, as recorded in the variant and engine data.

Engine code	1AD-FTV 2.0 D-4D
Configuration	I4, turbocharged · 1998 cc
Fuel / injection	diesel · common rail
Model years	2009–2015
Facelift phase	Sold either side of the 2015 facelift, 2009–2014 pre, 2015 LCI
Power / torque	126 PS · 310 Nm
Transmissions	6-speed manual
Gearbox families
Drivetrain	FWD
Economy (real-world)	4.8–6 l/100 km mixed
Markets	EU

2.0 D-4D 1AD-FTV

Overview

Pre-facelift or facelift, this engine spans both

Known issues, ranked by expected cost

Pre-purchase inspection

1Static checksEngine off, ideally on a lift.

2On the driveInclude low-speed manoeuvring, not just an open road.

3PaperworkOn these cars the folder is most of the value.

4OBD scanMandatory. A seller who refuses a scan has answered the question.